Category: Kubota dpf delete

Kubota dpf delete

This very common failure occurs when the DPF gets old or fails to regenerate as per the normal factory regen process. This has been known to leave people stranded in the bush, in remote country towns or when 4 wheel driving. A DPF Removal Service we are offering worldwide means that we can correct this problem from ever happening again. In short, we can help correct problems with DPF and poor performance at the same time. For more information please call us on 02 Then we are done.

You then have the opportunity to experience the amazing results from the first time you test drive the vehicle. This is removed into the atmosphere, simply removed from the gasses that flow through the exhaust to help lower emissions.

There are two types of Regeneration processes which will be explained further below. At this point it is recommended that you try to find time to complete a full regeneration and this can be done on a simple 10 minute or so drive of speeds above 80kph.

By now, driving at speed alone will no longer be sufficient and the car will need to go to a garage or dealership for regeneration. The other lights may be the engine management light constantly on and possibly even the glow plug light blinking constantly. It is not advised to continue driving the vehicle under these conditions to avoid further costly damages to the DPF system and other mechanical components e.

Not with us! Though it is illegal to remove any emission device if the system leaves the car incapacitated then removal is the only option. This can be confirmed by any government motor vehicle facility. The vehicle is not fit for its intended purpose with the DPF installed. Worse still is going into limp mode in a remote location or driving with the caravan or boat up a big hill with a truck barrelling up the road could very well put you and your family in a life threatening situation.

Also, truth be known, there is no road-side testing in Australia for diesel particulate at time of writing. For more information on this and how we can help, please contact us at sales chiptuning. The staff at Chip Tuning wish to extend our prayers for the families of those that are personally and intimately affected by the Coronavirus.

As you are well aware by now, the Coronavirus is causing severe problems to the global community. Safety measures currently in place in Asia are helping to combat this outbreak, however these same steps have serious consequences to the production of many components utilised in the Automotive industry.

Whilst committing to our best efforts to reduce the impact of this situation, we cannot avoid the fact that there will be delays in the production and delivery of our goods.

kubota dpf delete

Home Why Us? NB: NSW vehicle owners need to be aware that it is an offence to use a vehicle on any road or roads related area in NSW if any anti pollution device has been removed unless the vehicle is being used in motor racing or off road motor sports. Other Countries, States and Territories may have similar restrictions.

Passive Regeneration? Active Regeneration?If you are reading this you have or are thinking of deleting your DPF Diesel Particulate Filter and before you do, you need to consider all possibilities and repercussions.

As most of you know, the EPA has found the need to come down with an iron fist on emissions and specifically on the diesel market.

They were possibly the biggest name in diesel performance at the time and made some serious waves in the automotive aftermarket. If you are like most, you are facing or have faced this choice of needing to find a way to clean the DPF, replace the DPF or remove it all together which for the record Washington lawmakers, we do not condone!

So what do you do? Break the bank on a new DPF only for it to cause detrimental damage again in the future, delete it and get performance and mileage gains and possibly face legal repercussions? This is a huge debate and further more a daily moral battle for diesel truck owners.

kubota dpf delete

Maybe not tomorrow, but a few years from now we can all expect to be under laws just like California and we will need to seek alternatives for deleting the DPF. Our honest to god recommendation to you, should you decide to remove a DPF is to keep it! As an industry, I hope to see Top tuners and exhaust manufacturers start planning for this seemingly hopeless future so we can live on pushing the limits of diesel performance and seeking out the best performance tunes without the need for a DPF delete.

I also feel that their roles in what we do with our vehicles is absolutely no concern of theirs! It sounds more like they are creating job security for themselves. We do not condone deleting any On road vehicle.Forum Rules. Home Forums Reviews Articles Store. Homepage Today's Posts Search Register. Forgot your Password? Sign Up. Remember Me? Page 2 of 3 First 1 2 3 Last Jump to page: Results 11 to 20 of Originally Posted by sixdogs.

Reply With Quote. I read somewhere that there is a company in England that makes the dpf eliminator that also includes a computer chip or something like that. At the time I thought it was a bit pricey. You might google dpf eliminator and see what happens. Just looked up dpf delete and there is a bunch of info. Originally Posted by SDT.

When this last happened, the engine was at WOT. After mowing for about 10 minutes, I noticed that the regen lamp was on. Continued to mow for about 5 more minutes until the area that I was working on was finished.

Wanted to return to barn now but decided to waste time and fuel with make work to allow the regen process to complete. Afraid to reduce throttle. Engine abruptly shut down at WOT with rotary cutter bush hog type at full speed. No beeps, warnings or error codes.

Blades slammed forward and jammed. Very annoying. Engine would not restart until after lengthy cool down. Fortunately tractor on slope so could push out of road.

Kubota wants to check pump and injectors. I believe this to be a waste of time but not my decision. Believe replacing expensive reformer best bet to correct or at least improve situation, but very skeptical.

Taking care of your DPF is easy with Kubota Engine America

Frankly, do not believe that it can be made reliable with current design. Stay tuned. I was told that when that sensor sees a temp spike it shuts down the engine for safety. Might be that sensor is bad on yours? B, ZD and F Similar flawed technology in all. Spring is the season of optimism.Jump to content. You currently have javascript disabled. Several functions may not work. Please re-enable javascript to access full functionality. Posted 18 March - AM. Now I know why Caterpillar has you learn where the ECM fuse is on there current series of skid steers!!

Posted 18 March - PM. Posted 19 March - AM. It is under warranty so the engine will get replaced for sure.

My question is : is all this crap really nessesary on tractors?

kubota dpf delete

I can see it for trucks and cars but tractors too? It does not help the diesel reputation when these high school mentality fellas "roll coal" blacken the sky with altered emissions.

That gives folks the idea that diesel is just plain nasty. Since low emission sulphur diesel was mandated, that alone made a huge difference in diesel pollutant emissions Posted 19 March - PM.

Yah, high school kid that used to work for us was looking at a kit to activate the waste gate on the turbo at will on his cummins.

So he could roll massive coal at will was the answer. Proceeded to educate him about what all the unburnt fuel does to your oil and cylinder walls.

Posted 20 March - AM. Posted 22 March - AM. If'n that was my tractor, and it was on payments, I'd be telling Kubota I'm not giving them another dollar until they replace the engine or replace the tractor.

I don't care whether it ran away on fuel or engine oil! Javascript Disabled Detected You currently have javascript disabled. Kubota re gen issues. Page 1 of 2 1 2 Next. Posted 18 March - AM Friend I work with just bought a brandy new 47hp tractor with loader and hoe on the back. Anyways just got it back from the dealer for its very first service at 50 hrs We get a rippin' snow storm so he fires up his kubota and lets it warm up a bit while cleaning off the snow and it goes into re gen mode.

Yea buries the tach and keeps right on truckin'! Oh yea turns exaust yellow he tries to chop the throttle. It would not turn off!

DEF Delete – Disable The DEF / SCR System Instantly

He runs and calls dealer wondering what the heck is going on. The hard way, they ask him to try and restart it. What in the world could have happened? Do these little rigs use def fluid during regen?Forum Rules. Home Forums Reviews Articles Store. Homepage Today's Posts Search Register. Forgot your Password? Sign Up. Remember Me? Page 1 of 3 1 2 3 Last Jump to page: Results 1 to 10 of Has anybody out there had any luck with removing or disengaging the DPF?

I live way out in sparsely populated county far away from any cities or areas with polluted air, so a little particulate wouldn't be measurable a lot less than the dust I kick up just driving it! Seems to me that just driving with a normal muffler would work without the hassle of doing a parked regen every 20 hours or so.

Also how much air pollution is emitted by the the regen process? Which seems like a waste of fuel too! Not to mention down time. I'm seriously thinking about switching out the DPF with a standard exhaust system. Has anybody done that, and if so, were there any problems? Reply With Quote.

I don't think it is as easy as swapping the exaust out;computer controlled? You should not have to perform parked regents if the system is working properly. That said, the original software used in a B was quite problematic. If your engine ECU has not been updated with current software in say the last months it would be worth having this done. Remember the emission system is covered by warranty for 5 years by EPA mandate. Spring is the season of optimism.

Originally Posted by John Bottcher. Check with kubota to make sure you have the total update package. It regenerates every 15 hours or so and the only way I know is the dash symbol lights. I run at rpms most of the time. Also I push the auto regen button whenever I start the tractor. My update included a new generator and larger left side of the hood to accommodate that.

The ecu was updated.

Kubota tractors – deactivation of EGR and DPF already possible

Magnet attached winter front. Additional insulation around the blower pipe. The tractor updates in the winter blowing or plowing snow when the temp is below zero.The good points for removing the DEF from your truck, one it will save you a lot of downtime when the truck goes into limp mode when the DEF system fails. If you have a fleet of trucks that have been imported to your country where DEF fluid is not available, your trucks will fail and lose half the power, this is where our DEF delete module comes in and will fix your truck.

A large fleet of trucks using the DEF system will use a lot of it, this has to be refilled on a daily basis. If the fluid is not properly stored it gets contaminated very easily which will cause all sorts of problems with the truck. This is made to ISO standard and its names can be different depending on what country your are in. Some companies out there will tell you it must be removed in order for the DEF delete box to work.

We manufacture our own DEF delete kits and make custom software for each box.

kubota dpf delete

We will not be held liable for any person or company fitting our DEF delete unit in a country where it is illegal, if you are exporting trucks or machinery to countries where DEF fluid is not available these boxes are for you. Any damage or personal injury related to the use or fitting of our emulator we will not be held responsible. It is up to the buyer to check local laws to see if the box can be fitted. Skip to content.

DEF Removal Is Illegal in Some Countries We will not be held liable for any person or company fitting our DEF delete unit in a country where it is illegal, if you are exporting trucks or machinery to countries where DEF fluid is not available these boxes are for you.Discussion in ' Skid Steers ' started by 7.

Log in or Sign up. Heavy Equipment Forums. Thank you for visiting HeavyEquipmentForums. Our objective is to provide industry professionals a place to gather to exchange questions, answers and ideas. We welcome you to register using the "Register" icon at the top of the page. We'd appreciate any help you can offer in spreading the word of our new site.

The more members that join, the bigger resource for all to enjoy. Thank you! Thank you for joining Heavy Equipment Forums! If you are new to forums we communicate with "Threads", please search our threads to see if your topic may have already been answered and if not then click "Post New Thread" in the appropriate forum.

This will allow all of our members to see your question and give you the best chance to be answered. After you've made a number of posts you will graduate to Full Member status where you'll see a few more privileges.

Following these guidelines will help make this the best resource for heavy equipment on the net. Thanks for joining us and I hope you enjoy your stay!! Welcome to HeavyEquipmentForums. Anybody know if its possible to delete the emissions equipment on Kubota skid steers? Joined: Sep 22, Messages: Location: utah.

I'm very interested to what others have to say as I've been very interested in doing this with my two excavators. I did a DPF delete on my Cummins pickup and it was entirely different truck! So far I haven't been able to find any info on anybody doing this on construction equipment. Joined: Oct 12, Messages: 3, Location: Canada.

Did you buy it or is it a lease? I wouldn't think you can do anything to a leased unit or a machine under warranty for that matter either. Welder DaveDec 8, We've got a Kobelco SKLC with the Fiat-Iveco engine instead of the usual Hino that they traditionally had and it's had all sorts of troubles with the DEF system luckily they were covered by warranty but it was still down for about a month at the dealer's shop.

We've looked all over the 'net for delete's but haven't had any success, seems you can find anything for pick-ups, semi's, and ag equipment but nothing for construction equipment. We came across an ad for 'DEF B Gone' a month or two ago and after having a salesman tell me they likely could set us up with a unit we were later told it only works on farm equipment by Taber Diesel in Taber, AB.


thoughts on “Kubota dpf delete

Leave a Reply

Your email address will not be published. Required fields are marked *